1. PRODUCT IDENTIFICATION
1. PRODUCT IDENTIFICATION
| Product Name : | Oberon G27 |
| UN Proper Shipping Name : | None allocated |
| Other Names : | None listed |
| Product Use : | Lubricating Grease |
| CHEMTREC, 24-HOUR EMERGENCY TELEPHONE NUMBER | |
| 1-800-424-9300 (Toll-free) | For United States and Canada |
| 1-703-527-3887 | In the event of an incident occurring outside United States and Canada |
2. HAZARDS INDENTIFICATION
| Health Hazards, General | Not regarded as a health hazard under current legislation. |
| Sensitization | No known information. |
| Carcinogengenicity | IARC: Not listed. OSHA: Not regulated.NTP: Not listed. |
| Teratogenicity | No data available to indicate product or any components contained at greater than 0.1% may cause birth defects. |
| Health Warnings |
Skin Contact. Repeated or prolonged
contact can result in drying of the skin. Inhalation. Heating can generate vapours that may cause respiratory irritation, nausea and headaches. Inhalation hazard at room temperature is unlikely due to the low volatility of this product. Eye Contact. Slightly irritating. Ingestion. Can cause discomfort. |
|
Route of Entry Medical Symptoms |
Other Information Inhalation. Skin and /or eye contact. Ingestion Medical conditions aggravated by exposure: Not determined. |
3. COMPOSITION/INFORMATION ON INGREDIENTS
| NAME | CAS NUMBER | PROPORTION | RISK PHRASES |
| Petroleum distillates |
6742-54-7 64742-65-0 |
30 to 50% | - |
| Residual Oils |
64742-57-0 64742-62-7 |
- | |
4. FIRST AID MEASURES
| Inhalation | Move the exposed person to fresh air at once. For breathing difficulties oxygen may be necessary. Get medical attention if discomfort continues. |
| Eyes | Rinse with water for at least 15 minutes. In case of irritation, seek medical advice. |
| Skin | Remove all contaminated clothing. Wash skin thoroughly with water and non-abrasive soap. Get medical attention if any discomfort continues. |
| Ingestion | Do not induce vomiting! Seek medical attention immediately. |
5. FIRE FIGHTING MEASURES
| Flash Point | 475 deg F COC, lowest oil |
| Flammability Limit - Lower (%) | 0.9 |
| Flammability Limit – Upper (%) | 7.0 |
| Flammability Class | No uniform Fire Code noted. |
| Extinguishing Media | Use: Foam. Carbon dioxide (C02) Dry chemicals, sand, dolomite. |
|
Special Fire Fighting Procedures
Unusual Fire & Explosion Hazards Hazardous Combustion Products Protective Measures in case of Fire |
Use water to keep fire exposed containers
cool and disperse vapours. Water spray may be used to flush spills away
from exposures and dilute spills to non-flammable. Volume and pressure increases strongly when heated. Risk of container explosion in fire. Acrid smoke / fumes. Oxides of: Carbon. Sulfur. Self-contained breathing equipment and chemical resistant clothing recommended. |
6. ACCIDENTAL RELEASE MEASURES
|
Personal Precautions Precautions to Protect the Environment
Spill Clean – Up Procedures |
Minimize skin contact. Keep product out of sewers and watercourses by diking or impounding. Advise authorities if product has entered or may enter sewers, watercourses or extensive land areas. Assure conformity with applicable government regulations. Non-hazardous substance. Collect in closed container. |
7. HANDLING AND STORAGE
| Handling |
Repeated or prolonged contact with this
material should be avoided in order to lessen the possibility of skin
disorders. It is essential that all who come into contact, maintain high
standards of personal hygiene i.e. washing hands prior to eating,
drinking or going to the toilet. Build-up of mists in the working
atmosphere must be prevented. Misuse of empty containers can be hazardous. Do not cut, weld, heat or drill containers. Residue may ignite with explosive violence if heated sufficiently. Do not pressurise or expose to open flame or heat. Keep container closed and bung in place. |
|
Storage Precautions
Storage Criteria |
Store in a cool, dry, well-ventilated area,
out of direct sunlight. Avoid sparks, flames, and other ignition
sources. Store away from incompatible materials such as materials that
support combustion (oxidising materials). Chemical storage |
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
| Exposure Limits |
No value assigned for this specific
material by the National Occupational Health and Safety Commission (NOHSC).
However, Exposure Standards for constituents are listed below SUBSTANCE TWA STEL
ppm mg/m3 ppm mg/m3 Oil mist, mineral - 5 - 10 Exposure Standard means the average concentration of a particular substance in the worker’s breathing zone, exposure to which, according to current knowledge, should not cause adverse health effects nor cause undue discomfort to nearly all workers. It can be of three forms; time-weighted average (TWA), peak limitation, or short-term exposure limit (STEL). |
| Biological Limit Values | No biological limit allocated. |
| Engineering Control |
Use engineering controls to reduce air
contamination to permissible exposure level No specific ventilation requirements, but forced ventilation may still be required if air contamination exceeds acceptable level. |
| Respirator Type |
No specific recommendation made, but
respiratory protection may still be
required under exceptional circumstances when excessive air contamination exists. |
| Eye Protection | Chemical safety goggles are recommended. If handled hot, a full face shield should be worn. |
| Glove Type | Chemical resistant gloves required for prolonged or repeated contact. Use protective gloves made of latex. |
| Protective Clothing | Clothing should be suitable to avoid product contacting the skin on a prolonged or repeated basis. |
9. PHYSICAL AND CHEMICAL PROPERTIES:
| Appearance / Physical State | Tan / grease |
| Odour | Mild, bland petroleum odour |
| Melting Point (oC) | Not applicable |
| Boiling Point (oC) | Not applicable |
| Vapour Pressure (mmHg) | Less than 0.01 mm Hg @ 20 deg C |
| Vapour Density (air = 1) | Greater than 5 |
| pH | Not applicable |
| Specific Gravity (H20 = 1) | .96 @ 60 deg F |
| Flashpoint (deg F) | 475 deg F (COC) |
| Flamm. Limit LEL (% by vol) | 0.9 |
| Flamm. Limit UEL | 7.0 |
| Solubility in Water | Negligible: less than 0.1% |
| Evaporation Rate (Butyl Acetate=1) | Less than 0.01 |
|
|
10. STABILITY AND REACTIVITY
| Stability | Stable under normal conditions of storage and handling. |
| Conditions to Avoid | Avoid contacts with acids and oxidizing substances. |
| Incompatible Materials | Strong oxidising agents. |
| Hazardous Decomposition Products | Oxides of carbon. Sulfur. |
| Hazardous Reactions | No hazardous polymerization will occur. |
11. TOXICOLOGICAL INFOMATION
| Toxicology | No toxicological data available for this product. |
| Acute - Swallowed | Small amounts of liquid aspirated into the respiratory system during ingestion or from vomiting may cause bronchopneumonia or pulmonary edema. |
| Acute - Eye | Will cause eye discomfort, but will not injure eye tissue. |
| Acute - Skin | Prolonged or frequent contact may cause skin irritation or cracking to sensitive skins. |
| Acute - Inhaled: | Vapour concentrations above recommended exposure levels may be irritating to the eyes and the respiratory tract, may cause headaches and dizziness, could be anaesthetic and may have other central nervous system effects. |
| Chronic | Prolonged or repeated contact with this material may result in skin irritation leading to dermatitis. |
12. ECOLOGICAL INFOMATION
| Ecological Information | No data on possible environmental effects have been found. |
| Bioaccumulation | Not determined. |
| Acute Aquatic Toxicity | Not determined. |
13. DISPOSAL CONSIDERATION
| Disposal Method | Spilled material, unused contents and empty containers must be disposed of in accordance with local, state and federal regulations. |
| Special Disposal Precautions | None allocated. |
14. TRANSPORT INFORMATION:
| UN Number | None allocated |
| UN Proper Shipping Name | None allocated |
| DOT Hazard Class | Not regulated. |
| Packaging Group | None allocated |
| Hazchem Code | None allocated |
| Special Transport Precautions | None allocated |
15. REGULATORY INFORMATION:
| US Federal Regulations | ||
|
Regulatory Status
SARA (311/312) Hazard Categories State Regulatory Status
Controlled Product Classification |
This Product or its components, if a
mixture, is subject to following regulations (Not meant to be all
inclusive-selected regulations represented): TSCA: The ingredients of this product are on the TSCA inventory. Section 313: This product does not contain toxic chemical subject to the reporting Reauthorization Act of 1986 and 40 CFR Part 372. Clean Air Act None US State Regulations This product or its components, if a mixture, is subject to following restrictions (Not meant to be all inclusive - selected regulations represented): Proposition 65: This product does not contain chemicals considered by the State of California’s Safe Drinking Water and Toxic Enforcement Act of 1986 as causing cancer or reproductive toxicity, and for which warnings are now required. Workplace Hazardous Materials Information System - WHIMIS Canadian WHMIS Classification Not a controlled product. |
|
16. OTHER INFORMATION
|
Health Flammability Reactivity Special Hazard NPCA HMIS Hazard Index NPCA HMIS Personal Protection
|
No health hazards specifically noted for
fire situations (0). Burns only if pre-heated (1) Not applicable (0) Not applicable Minimal Hazard (0) A
|
|
Prepared By IMPORTANT DISCLAIMER |
Laboratory Manager All reasonable care has been taken to ensure that the information and advice contained herein are accurate at the time of printing. However, Oberon Manufacturing Company Pte Ltd. accepts no tortuous or contractual liability for any loss or damages suffered as a consequence of reliance on the information and advice contained herein. |
靖玉貿易行銷有限公司
台灣 桃園市 326-46 楊梅區民族路 5 段 201 巷 124 號
TEL : 03-4206896 FAX : 03-4202206 http:www.jingyu.biz
